How to prevent hot water fired water tube boiler manufacturer in pakistan hot water boiler explosion released belong to special equipment, but also a high temperature and pressure of thermal equipment, there will be some failures during operation, these are normal, but if not handled properly is likely to occur hot water boiler explosion. So, for safety equipment and personal safety, we have to understand some common sense prevention hot water boiler explosion. M & E network in the boiler provides the following two methods: 1, the hot boiler explosion accident prevention boiler should be designed in strict accordance with the requirements of thermal calculation and strength calculation, structural arrangements should be fair, the selection should be qualified. Manufacture of boilers, construction plans should be to ensure conformity of the quality of the boiler delineated. Boiler safety accessories should be complete, agile and reliable, and maintenance schedule, often check on the failure of the annex should be replaced. Maintenance schedule by part of the boiler to the boiler, external maintenance, the existence of a timely topic for repair and reconstruction, to ensure test quality. 2, fuel, gas hot water boiler furnace explosion prevention hot water boiler furnace point to double-check each gas line, oil line is tight (leak), pressure is normal, Installation and reconstruction of new oil and gas pipelines necessary to purge and clean. Check the ignition lead before the drum whether the fan has to take the air 5 ~ 10min, after ignition failure to analyze the reasons, then the ignition process to take the air ignition. Boiler use permit and inspection certificate did not apply for the boiler, furnace stokers right to refuse point. Enterprises should have a great fireman layout of manipulating evidence of experience points furnace fireman, fireman staff should strengthen the inspection tour, identify problems in time to prevent stalling, stalling once found, should immediately cut off fuel boiler installation should be controlled protection, including automatic ignition , flame protection, automatic adjustment of combustion and the necessary alarm chain protection.

Gas fired water tube boiler manufacturer in pakistan maintenance gas boiler main composition characteristics of each system main components: burner: Burner collector,, oil, gas in one. High degree of integration, high degree of automation, is the maintenance of the boiler system at the focus. Boiler furnace: furnace boiler is the main component computer control system to achieve energy conversion: computer control system is the command center of the entire boiler operation is a core component of the boiler. Each maintenance system: burner maintenance: cleaning full turn cup burner, ignition means, filter, pump, motor and impeller system, throttle linkage arrangement lubricated. Re-awarded for combustion testing. The controller Maintenance: Maintenance detecting electrical components, control lines, the control box clean ash collection, each control point is detected. Finally sealed. Controller element to prevent the moisture. Water supply system maintenance: repair water treatment plant to check whether water quality standards, a comprehensive clean-water treatment system, to check the functioning of the pump head and check for each pipeline valves can be used flexibly and so on. Water and electricity, the system closes the valve after each filled with water. Furnace Maintenance: In order to make the boiler safe and economic operation lasting, must in daily use, strengthen the maintenance of the boiler. This is also to prevent lower thermal efficiency, an important measure to avoid the use of state of deterioration and boiler accident. Large font display temperature, easy to grasp and boiler operating conditions of the system, the water temperature can be freely set from 10 ℃ to 90 ℃, automatic boiler or heating system to provide users with life, bath with hot water. The control system controls the temperature of the boiler water circulating pump start and stop, boiler water circulating pump starts when the water reaches an upper limit temperature, lower than the hot water circulation pump stops when the water temperature lower limit. Horizontal bath gas boiler three return all wet back structure, using a large furnace, rough smoke tube design, increased furnace radiation heat absorption, the effective energy saving. Using threaded pipe and waveform furnace, greatly enhanced heat transfer effect, greatly saving fuel consumption. Machine equipped with thermal protection (ultrahigh temperature furnace, the burner is automatically stopped and an alarm buzzer, the second over protection (the boiler shell temperature exceeds 105 deg.] C, the secondary circuit is automatically cut off), anti-dry water protection (when the boiler water level is below low, the boiler is stopped and an alarm beep), a boiler leakage protection (the control system detects electrical leakage, short circuit, automatically cut off the power). press pressure boiler design, the boiler is no pressure state, there is no safety hazard. centrifugal using advanced multilayer insulation wool, a steel sheet for packaging famous white color, heat loss, appearance of anti-rust .573,

Vertical steam fired water tube boiler manufacturer in pakistan combustion characteristics combustion grate section with double action, heating up, fast boosting of unburnt gas through the secondary combustion, functions as combustion, smoke, dust. Bending the upper furnace tube arrangement convection heating region, disposed in the lower furnace grate tubes and radiation heating furnace area, structure of the furnace and the flue gas flow, reasonable layout, good heat transfer, the boiler reasonable design, simple structure operation, easy maintenance, small footprint, less investment in infrastructure, the company is one of small enterprises with steam, heating and other equipment ideal. Coal-fired steam boiler performance characteristics: 1, the furnace and comparing the old vertical boiler, heating area, rapid boost heating, less coal, high thermal efficiency, can save 25-30% of coal. 2, a furnace with multiple, user-friendly, the furnace can be used for the production of steam steaming canteens, disinfection tableware, bath heating, process steam, heating and the like locally heating the room. 3, the furnace with natural ventilation, induced draft fan and the blower does not need, no noise. 4, compact structure, installation, operation, easy maintenance, may be integrally handling, suitable flowability units. 5, heated with steam bath, food, heating, steaming, etc., pressure gauge scale strictly controlled within the design pressure, working pressure at any time shall not exceed the operating pressure. The scope of the steam boiler Application: can be used in textile, printing and dyeing, paper, food, rubber, plastics, chemicals, pharmaceuticals, iron and steel, metallurgy and other industrial products machining process required steam, and for enterprises, institutions, hotels, schools, restaurants, service industries such as heating, bath, air conditioning and hot water. Pledge: Since the equipment installation qualification pressure parts warranty 3 years, 12 months, auxiliary and lifetime maintenance, warranty period free of charge warranty for non-human failure (various defects caused by faulty equipment itself) of the Company, the replacement of damaged parts, the warranty period or man-made damage, is still responsible for maintenance and guidance equipment, for repair, replacement parts only fees. Quality assurance after the expiry responsible for maintenance of life.

In recent years, Hebei Province People's Government to respond positively to Blue Sky Battle action plan promulgated by the state, and all of 35t / h coal-fired fired water tube boiler manufacturer in pakistan and below in the Hebei province out of the transformation process. First Hospital of Baoding respond positively to the call of the provincial government, eliminate serious pollution of the original coal-fired boiler hospital, citing energy saving steam boiler to natural gas as raw material. After a series of market research, WNS Series Split hospital condensing gas boiler boiler other fast soft spot.