Commercial Factory Direct Supply 8t gas boiler Azerbaijan

Advancing the ignition point of coal, the temperature of the furnace to improve the ash carbon content decreased. Smoke swirling mix and strengthen the separation of coke particles in the flue gas, so that it falls on the fire bed and the new layer further fuel burn. Flue gas also strong swirl in the flue gas CO, H2, CH4 and other combustible combustion gases, thereby improving the thermal efficiency of the commercial factory direct supply 8t boiler azerbaijan is more than 4%. But also improve the boiler output to meet the needs of the production of steam, reducing environmental pollution, expanding the scope to adapt varieties of coal. 2. The air supply and reasonable regulation. In Grate, vibration stove, oven and forth, depending on the characteristics of the combustion process, reasonable air, to promote combustion furnace is very important. As the chain furnace, with grate the fuel is kept in motion, occur sequentially ignition, combustion, burn various stages. Along the longitudinal direction of the combustion grate stages, the partition, the amount of air required in the grate longitudinal direction is different. In the preheating zone of the head and the tail of burnout grate stage, small air requirement in the middle stage of combustion grate, the air amount required.

Lanzhou City, Gansu Province, the transformation of coal-fired commercial factory direct supply 8t boiler azerbaijan control policy in accordance with the latest introduction of the "not big on the small" principle to give "Yijiangdaibu" financial support to owners of units, specific subsidies are as follows:

1, for a single 1 ton / hour or more than 0.7 megawatts of clean energy and coal-fired boilers by 100,000 yuan to subsidize steam tons of standard /.

2, coal-fired heating boilers mentioned standard governance and meet the national air pollutant emission limits in particular boiler, according to subsidize 50,000 yuan / ton steam standards, subsidies does not exceed 30% of the total investment quota.

3, for a single 1 ton / hour or 0.7 megawatts of utility units (including schools, health centers, hospitals, neighborhood or township government offices and other public units) clean energy transformation of coal-fired heating boilers in accordance with the actual heating area subsidies, allowances of 100 yuan / square meter.

Coal-fired commercial factory direct supply 8t boiler azerbaijan economizer economizer effect to save the name suggests is a secondary member of coal fired boilers and the like for the device, the principle is to use the coal-fired boiler economizer flue gas heat exchanger for heating the feedwater. Economizer heat absorbing smoke, reduced exhaust gas temperature, by improving the thermal efficiency of coal-fired boilers, to achieve the purpose of saving coal. Secondly, in the coal-fired boiler feedwater into the drum, since the exhaust gas after the preheating heater temperature increased, reducing the temperature difference between upper and lower walls of the drum, the drum reduces the thermal stress of the upper and lower walls coal-fired boilers, to reduce the vertical drum wall temperature difference due to damage, protect the safe operation of coal-fired boilers, coal-fired boilers to extend the life of the road.

Boilers which are several general, in what is now the mainstream Why? 1, gas commercial factory direct supply 8t boiler azerbaijan advantages: efficient, clean, environmentally friendly, without manual operation, only need to monitor, small footprint, no transportation fuel, no need to deal with soot, due to the combustion of natural gas free of impurities, without corrosion damage to the boiler and related accessories long boiler life, defined as 15 years, but basically long-term use. Is now mainstream boiler, natural gas is the environmental protection sector, the government vigorously promoted. Cons: You do not know how much that gas prices are calculated according to the calorific value and thermal efficiency, generally bituminous coal per ton of coal (according to 5500 kcal / kg) is approximately equal to 350 to 400 cubic meters of gas. Probably a little slightly more expensive than coal. (No transport, area, ash handling, labor, etc. into the calculation). 2, oil-fired boiler, advantages: substantially the same structure and properties of gas boilers. Disadvantages: higher cost of natural gas is 2 times the boiler, diesel transportation, storage more dangerous, accident-prone. And the domestic diesel supply is unstable, easily interrupted. 3, coal-fired boilers, the advantages: the economy. Disadvantages: 1, requires a lot of ash and coal yard area. 2, a boiler fireman for 4 to 8 people. 3, boiler room and coal yard is very dirty. 4, noise, emissions of dust, nuisance. 5, environmental protection departments often to check an inattentive, he was diagnosed with excessive emissions, maintenance shutdown, fine, very troublesome. 6, coal sulfur content are more severe corrosion of boiler, 10 to 15 years after the basic unusable. Summary: Due to high oil prices and supply unstable now, and now oil-fired boiler has been temporarily withdrawn from the market. Natural gas prices due to regional differences are very different, although you are not sure where the price of natural gas, but natural gas in most parts of the domestic coal is relatively expensive, (only in Sichuan, northwest of cheaper natural gas). Especially large industrial boilers, more fuel, the cost difference is more obvious. Coal-fired boilers to heavy air pollution, with the country on environmental issues more and more attention, more stringent emission requirements for coal-fired boilers, a lot of urban cities, has stopped the examination and approval procedures coal-fired boilers. It is recommended that, if your organization is not large tonnage production of boilers, installation of gas boilers or better, although with a little more than fuel costs, but in the actual operation of the process, you can save a lot of things, while saving area, the environment is clean.