delicate processing gas pressure water tube boiler

Gas delicate processing pressure water tube boiler Burner Failures and gas boiler burners Failures and - best  a gas boiler, gas boiler burner ignition misfire rod reasons: 1, the ignition bar gap interposed carbon residue with oil. 2, ignition rods fragmentation. moist. Leakage. 3, the distance between the ignition does not stick, too long or short. 4, ignition rods Insulation damage, short to ground. 5, ignition cable and transformer failure: cable, connector damage caused by a short circuit during ignition; transformer break or other fault occurs. Measures following five: Clear, renewal, adjust the distance, change and switching transformer. Second, gas boiler, but spark ignition rods misfire reasons: 1, the cyclone disc space ventilation is blocked carbon, poor ventilation. 2, dirty oil nozzle clogging or wear. 3, the throttle angle is set too small. 4, the firing bar from the leading edge from the oil nozzle tip inappropriate (too protruding or retracted) 5, the first solenoid valve is an oil debris blocking gun (gun small kerosene). 6, oily or too viscous to flow easily clogged or the oil filtration system the valve is not opened, so that insufficient suction pump, oil pressure. 7, the filter pump itself blocked. 8, the oil more water (boiling abnormal noise within the heater). Measures are: Clear; first wash, such as not renewed; turndown test; adjusting the distance (in 3 ~ 4mm as well); Remove cleaning (cleaning the parts diesel); Check tubing and oil filters, insulation equipment ; remove peripheral screw pump, carefully remove the cover inside out oil network, with immersion oil; renewal of the test oil. Third, when the gas boiler and turn the fire a small fire normal, off, or flashing instability reasons: 1, the air volume damper setting fire too. 2, oil fires micro switch valve (damper outermost that group) inappropriate setting (set throttle air flow rate is greater than the fire). 3, oleaginous easy to spray viscosity is too high (heavy). 4, and the nozzle plate spacing cyclone inappropriate. 5, fire nozzle worn or dirty. 6, the preliminary fuel tank temperature is too high, so that the steam not smooth oil pump oil feed. 7, fuel oil boiler water. Action: Test gradually reduced; heating temperature; adjusting the distance (between 0 ~ 10mm); clean or replace; approximately set to about 50 deg.] C; or drain oil change. Fourth, the noise increases gas boiler burner reasons: 1, cut-off valve is closed or the passage into the fuel shortage, an oil filter blockage. 2, the oil inlet temperature is low, the oil viscosity is too high or the temperature is too high the pump inlet. 3, oil pump failure. 4, fan motor bearing damage. 5, dirty fan impeller. Processing methods: ① the oil line check valve is open, if the oil filter is working properly, the filter cleaning pump itself. ② heating oil or reduce the oil temperature. ③ Replace the oil pump. ④ replace motor or bearings. ⑤ cleaning fan wheel.

1.4 mw natural gas hot water delicate processing pressure water tube boiler used in a hotel

2.8 mw coal hot water boiler for district heating

Recently, Xi'an, Shaanxi Province take minus coal, train control, dust suppression, government sources, prohibiting other measures, the air pollution caused by human factors reduced to very low, efforts to improve air quality in Xi'an winter. As of early November, Xi'an has cut 100 million tons of coal-fired, 15 high-ranked companies relocate or shut down.

In 2018, the Shaanxi provincial government issued a formal mandate to inform, Xi'an total of 140 million tons of coal to reduce the task, mainly around the Xi'an city government to cut electricity, central heating boilers Chaigai, urban and rural residents scattered coal and gas supply security in four areas of governance to carry out jobs. As of the end of October this year, has cut coal 1.015 million tons, completed 70.7% year plan. Built area of ​​29,419 catering units are the use of clean energy, outside built-up area 5196 catering units are to switch to clean energy.

Vehicle exhaust is one of the sources of atmospheric pollution. In order to strictly control the "black tail", environmental management staff at the three-ring along the line, passenger stations, farmers market, food stores and other black smoke high incidence of vehicle checkpoints set up 423-bit, low-speed vehicles investigated a total of 71,300 cases to go cut the line , black smoke car 7027 cases.

In the "anti-summer period", Xi'an continue to implement the motor vehicle limit line of control measures, and completed the 3255 update of pure electric buses put into operation, the completion rate of 102%. Newly started construction of public parking spaces 12,908, 86.1% completion rate. Investigate ChaoBiaoChe 3504.

In terms of the source rule, Xi'an cumulative Mopai "scattered dirt" Enterprise 21021 (including New West Ham), complete renovation 8163, completion rate of 38.8%; 15 high energy consumption, high emission enterprises to complete the relocation or shut down; 3399 Taiwan low nitrogen gas boiler to complete the transformation, the completion rate of 99.4%.

40 industrial enterprises complete control of volatile organic compounds, the completion rate was 88.9%; 26 224 restaurants and stalls point to install smoke purification facilities; 1259 spray paint auto repair business to complete in-depth treatment of exhaust gas, and all the installation of pollution control equipment independent meter; the Third Ring Road 336 gas stations outside the full completion of the transformation of tertiary recovery of oil and gas, and all the installation of pollution control facilities separate meter.

In terms of prohibiting, Xi'an completed summer crop straw comprehensive utilization area of ​​249.82 acres of mechanization, comprehensive utilization rate of 95.4%, exceeding the target task. At the same time, organized and implemented six acres and nine provincial and municipal straw utilization demonstration projects, compared with the provincial target increase of 12.5 percentage points; investigate and deal with the problem of black smoke burning from 457; 8 consecutive years of summer and autumn straw Jinshao to achieve "zero fire point" goal.

This year, the Xi'an handled a number of prominent air pollution problems. City of iron-fisted rule examination revealed a total haze to do all kinds of air pollution problems 1862, the city set up a team of 153 people to strengthen the supervision and inspection found problems common enterprise 6128, cross-check inspection found a total of 11,781 business problems. These issues are issued under the supervision of the list of issues to be reform.

The advantages of gas steam delicate processing pressure water tube boiler Gas steam boilers advantage: designers will arrange commandment information again, simple and convenient operation of the facility. Gas-fired steam boiler is not only easy to operate, and as soon as possible to ensure the safety factor used. Energy-saving advantages: high-temperature gas steam boiler with characteristic base pressure, greatly reducing the use of water pressure level heating facilities, to immediately benefit from lower capital injection facilities. Also said that the proportion of raw materials and gas touched. Only proper and adequate oil ignited gas can produce ratios exceeding ignite rate, together with its ability to reduce vapor emissions and maintain two-way power-saving, very convenient. Gas steam boiler can be arranged according to the specific needs of the amount of vapor, reduce renewable resource conservation. The higher the specific requirements and the intermediate supply pairing methodology, the higher the power saving effect. The heat exchanger can continue to use sewage water calories, and thus can increase oxygen supply and drainage of water temperature. In accordance with the provisions of the Environmental Protection useless now need, doing everything, gas-fired industrial equipment is more commonly used. In severe conditions, serious vapor watering, the water content of the salt to enhance the micro gas steam boiler, water hammer audible in steam lines, steam splashing outwardly coupling joint living; or furnace tube if economizer line split, water vapor allowance is given below, when less water is generated, in turn, the situation will occur; less water when severe, it is possible to see the red water wall of furnace tubes can also smell burnt taste. Together, furnace tube will split, could hear explosions. Steam and smoke exclude the furnace mouth and fire security door from. Low water interlock device, if the amount of water is less than the target value, air-conditioning fan, booster fan and grate machine motor reducer operation should be terminated; Security Council water is less than the low water mark, water glass (plate) is black; cleaning sheet is not water clear micro gas steam boiler is not filled or slightly severe filled with water? Ways: first turn off the water level gauge, tap water pipe is connected, and then open the drain cock. If you can see the water line from the top lower, then it is filled with a little water, open the drain valve and place no problem of water. If severe filled with water, please use the emergency shutdown countermeasures.