11 tons gas steam boiler in Pakistan

What is the reason for 11 tons steam boiler in pakistan explosion? Boiler itself is flawed: the pressure component aging, strength weakened, or leakage, corrosion, deformation, scaling and other defects can not be timely maintenance and eliminate hidden dangers, but let the disease run with the boiler and so on. Fuel gas boiler is not only fuel but also refers to the gas boiler. Previously no such dual-fuel boiler, burner because either fuel or gas, no dual fuel burners. With the rapid development of the world energy equipment, some European countries begin production and sales of fuel gas burner, dual fuel burner and boiler combination of organic birth of a new breed of boiler - fuel gas-fired boiler. Therefore, we must carry out regular inspection of boilers in accordance with national requirements. 3. poor management, furnace workers irresponsible or low levels, lead to misuse. Therefore, furnace workers must obtain a certificate as required. None of the above is the main reason for the actual boiler explosion. In actual operation, the most common situation is that the boiler add cold water and drying, which is very dangerous. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass hot water boiler, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. This is also the operators need the most important thing vigilance. There may be debris blocking the pressure cooker vent, causing the pot to continue to increase pressure, excess pressure can not be discharged to reach the pot of strength, can withstand the pressure will naturally explode, of course, does not rule out the cause of pan itself. Substandard quality, tank leaks, inadequate exhaust usually cause an explosion. Therefore, before use, carefully check the vent is smooth, not to violate the specification and taboos, without any danger.

Combustion characteristics and operation of 11 tons steam boiler in pakistan steam for steam boilers everyone know how much will the following to let everyone have a preliminary understanding of the steam boiler by two aspects, but also hope to give a friend wanted to buy a steam boiler of some help. Chain-type layer is generally fixed combustible fuel steam boiler chain grate or a grate (the traveling), it is fixed only for small coal-fired boilers. The most commonly used medium-sized coal-fired boilers or for chain grate, as the chain travels will gradually sent to the tail of the coal grate in the process of moving complete fuel combustion tube from the inlet to the lower part of the grate grate internal supplemental air required for combustion, ignition top-down, no ventilation grate uneven seam and around the relative movement, through non-flammable. After heating area of ​​the heating flue gas temperature of the working fluid designed to flow through the same furnace hot flue gas and heating surface arranged in the other exhaust flue boiler. Incidental chain grate type, scale type, beams, and other means, the current domestic applications mainly for small and medium-sized joint type and scale type chain grate, generally large chain grate beam type. Former steam boiler steam boiler system to start all waterproof steam cylinder valve open, let go condensate. The inlet steam valve slightly open, to warm up the cylinder, drain cocks to be out after closing the steam, drain cocks. The steam valve was then opened progressively larger until drainage tank vent cock and water out there, and closed vent cock drain cocks. Turn on the water supply valve to the boiler feed water. Steam boiler in operation if there is gas in timely attention tank, water tank periodically open the air discharge valve, in order to avoid air resistance tank, the influent. Pump flow regulator bypass should be adjusted to achieve the degree of opening of the valve, and not with a method of adjusting the outlet valve is adjusted. At the rated discharge pressure of the pump, which inlet pressure should not exceed a predetermined value. Inlet and exhaust pressure difference should be maintained within a predetermined range. Steam boiler steam valve should be shut down first, then turn off the water valve and turn on the water valve is open, then turn on the water faucet open the lower part of the tank and cylinder, the cylinder water drain. Of steam cylinder reciprocating pump, which cylinder two stroke difference should not exceed 5% of rated travel.

Dezhou City, Shandong Province issued - an important part of "Dezhou 2018 2020 coal consumption reduction alternative work" (the "Program"), the Yajian coal consumption as an ecological civilization construction and environmental protection work, and resolutely fight pollution prevention tough fight. "Plan" put forward, as of 2020, total coal consumption Dezhou control in less than 18.5 million tons, clean heating rate of 70%.

According to "program" requirements, Dezhou vigorously for shutting down the environmental, energy, security and other 300,000 kilowatts of coal-fired units of non-compliance, especially running at least 20 years of pure condensing units and over 25 years of condensate pumping thermoelectric unit. At the same time shutting down out of small coal-fired boilers to reduce coal pollution. Upon completion of the city's 10 steam tons / hour and coal-fired boilers are all clear on the key areas in national, provincial and determined basically eliminated 35 tons of steam / h coal-fired boilers, 65 tons of steam / hour or more coal-fired boilers completed energy efficiency and ultra-low emissions transformation.

Dezhou will also expand the scope of central heating, promoting clean urban and heating, 2020, the Center City District (Germany City, Texas Economic Development Zone, the Canal Economic Development Zone) central heating area of ​​45 million square meters, the other 10 counties (cities, districts) central heating area of ​​41 million square meters, the implementation of central heating pilot projects in rural areas where conditions permit. For areas not covered by central heating, according to the resources in the area of ​​heating conditions, combined with infrastructure construction, promote the substitution of gas for coal to other electricity-generation clean energy alternatives such as coal and biomass. As of 2020, Dezhou city's average clean heating rate of 70%. Among them, the city basically clean heating comprehensive coverage, average clean heating in rural areas reached about 55%.

In addition, Dezhou will continue to increase the proportion of natural gas consumption, substitution of coal consumption, encourage the development of direct supply of natural gas to large users to promote key industrial enterprises, industrial parks to achieve direct supply of natural gas. By 2020, increase the proportion of natural gas consumption in energy consumption to about 7%.

Gas 11 tons steam boiler in pakistan which safety devices 1, real-time monitoring water: water with electronic detection devices, real-time monitoring .2 boiler water level, time setting function: the user can be freely set in combination boiler stop time from .3, leakage protection: the control system upon detection of leakage electric heating elements will automatically cut off power .4, water protection: when the time to cut off water gas boiler burner control circuit to prevent the occurrence of dry damage the burner, while the controller sends missing .5 water alarm indicator, power protection function: gas steam boiler immediately stopped .6, overpressure interlock protection: when the boiler pressure exceeds the user set value, the burner operation is prohibited and the alarm .7, pressure controller, water level alarm, safety valve, low water level alarm and other multiple security .8, and the complete gas train protection system: to provide the filter, regulator, solenoid valves and accessories such as a complete gas train to ensure that the gas .9 safety, flue gas monitoring means can automatically monitor the exhaust gas temperature of the boiler, more easily grasp the combustion boiler.