Distributor Commercial 6t gas steam boiler Singapore

How to observe whether distributor commercial 6t steam boiler singapore is short of water and how to deal with itSteam boiler is a kind of energy conversion equipment. The energy input to the boiler is chemical energy in fuel, electric energy, heat energy of high temperature flue gas and so on. After boiler conversion, steam, high temperature water or organic heat carrier with certain heat energy is outputted out. Water level below the minimum safe water level, or invisible water level, water table glass tube (plate) appears white. The two-color water level meter shows all the gas-phase indication colors. Low water level alarm signals occur in high and low water level alarms. Low water level interlock device, water level below the specified value should stop the operation of fan, induced fan, grate reducer motor. There is also a sharp rise in superheater steam temperature above the normal outlet Steam temperature. The exhaust temperature of the boiler rises. The feed water flow rate is smaller than the steam flow rate, if the furnace tube or coal economizer tube rupture cause water shortage, the opposite phenomenon will occur. When the water shortage is serious, you can smell the scorching smell. When water shortage is serious, red water wall tube can be seen from the furnace door. When the water shortage is severe, the furnace tube may break, and a burst can be heard, steam and smoke will be ejected from the furnace door and the fire door. By calling water; for severe water shortage, it is necessary to stop the furnace urgently, and blindly feed water to the boiler. Reduce fuel, blast, draw wind, and supply water slowly when water is classified as a slight water shortage.

The reason the gas boiler burner noise analysis increases in the use of gas-fired boiler, found a small fire is normal, but when it becomes a fire goes out or flashing instability. First, because of excessive wind fire damper is provided; secondly, because of the fire valve microswitch (outermost damper group) is set incorrectly (fire damper is set larger than the amount of wind). Fuel circuit closing valve or port into the oil shortage, an oil filter plugging, increased gas burner boiler noise; Alternatively, since the oil inlet temperature is low, the viscosity is too high, the oil feed pump temperature, pump failure, fan motor bearing damage, and because the fan impeller dirty equipment, resulting in noisy equipment. Gas boiler in the course of the above failures, the viscosity is too high to spray the oil (heavy oil), and improper nozzle plate from the cyclone, and the like due to worn or dirty nozzles plus reasons. May be due to too high a heating temperature of the tank, leading to the steam delivery oil pump is not smooth; or because the fuel oil boiler caused by the water content. In use the gas boiler, the above failures should be gradually reduced, the heating temperature, to adjust the distance (0 ~ 10mm), cleaning or replacement should be about 50 ℃, the heating temperature should be raised. Oil change or drainage.

Wuhan Yu Dahua Group Co., Ltd. is a cotton based, weaving, knitting and textile car decoration installation in one of the cross-industry, diversified and comprehensive export-oriented enterprise groups. 2017, the Group expanded production scale textile processing, the number of new production lines, the Group's original distributor commercial 6t steam boiler singapore can not meet the growing demand of orders in urgent need of a new steam boiler purchase. When selecting vendors steam boiler, the boiler output device side fast sustainable high quality steam attracted, decided to cooperate with the fast boiler. Fast art by side to the user site needs analysis, to provide two integrally condensing gas steam boiler (WNS4-1.25-Y.Q).

Henan gas boiler tube leak detection device alarm Fault Henan furnace gas boiler tube leak detection device can be checked promptly internal gas boiler heating surface Henan leak case, can effectively protect other heating surface tube row, ensure the safe operation of the economic unit. 1. Symptom: (1) one side surface of the entire heating furnace tube leak detection alarm device. (2) concentration of several parts tube leak detection alarm device. 2. Analysis: (1) Henan compressed gas pipeline leak around the boiler emits different sounds. (2) sootblower valve lift Jam, steam leakage. (3) heating surface tube bank or weld leak squib. 3. Treatment: (1) contact electric inspection personnel. (2) no abnormal sound in Henan gas boiler furnace, whether near the flange of the compressed air line check alarm leak detection means has tube leaks and timely manner. (3) Check the tube near the sootblower alarm if a valve lift leakage detecting means there are leaks and timely manner. (4) such as opening hole to see the fire, obviously abnormal sound in the gas boiler furnace Henan, Henan description gas boiler tube leakage indeed, organizers prepare repair. 4. precautions: (1) strengthen inspection. (2) Electric regularly cleaned and checked Henan gas boiler tube leak detection means. (3) make Henan gas boiler tube leak repairs should be tight plan.