20 th dual fuel and gas steam boiler

The use of gas 20 th dual fuel and steam boiler added to give businesses what benefits? National emphasis on energy conservation increased year by year, which also contributed to the gas steam boiler flourish among industry, under the premise of environmental policies and to efficiency gains, companies are willing to choose both energy-saving, and high thermal efficiency of gas-fired boiler. Gas steam boiler in addition to providing sufficient high-temperature steam, but also can reduce fuel cost by reducing the combustion load input. The use of gas steam boiler will bring any significant benefits, let's take a look. 1, the biggest benefit is the economic use of gas steam boiler can save a lot of fuel costs for businesses, you do not need to spend lots of money to purchase a large amount of coal fuel, just use good cleanliness of natural gas will be able to output enough steam; they also do not We need the fuel storage site, only need to connect to the pipeline. 2, security is well known that natural gas is a very safe and stable, non-toxic and pollution-free, good cleanliness of fuel, liquefied petroleum gas or gas leak after not deposited on the ground, and even cause accidents will burn again. Process gas steam boiler during conveying gas selected gas is the most secure, but also easily found after leakage during use and therefore is the most secure way. 3, convenient gas steam boiler in the use, operation is very convenient, so will much favored by all walks of life. Because the use of all natural gas pipeline, a sustained run without any problems. Eliminating the need to transport coal use and clean-up or stacking cinder and other tedious work. 4. Clean the reason why gas steam boiler in the market to get a high rating, but also because it is clean and not contaminated during use, and does not produce black bottom of the pot, there is no air pollution. Thus, in use, compared to other boiler is the cleanest way.

Operation of the boiler, including what? Including the operation of the boiler, what does? Following on from the Henan fast boiler company to tell you about: 1. The water level regulation of normal water level in the middle of the gauge (1) of the boiler. Operation with the magnitude of the load is adjusted: to maintain a high level during low load, high load to maintain a low level. Changes should not be down more than 40 mm. (2) to be run on the water level gauge to compare the two groups, if the water level display should be corrected promptly identify the cause. (3) To achieve a balanced continuous boiler feed water, ground water supply, water supply less, to maintain the water level in the normal water level fluctuates slightly in the vicinity. (4) load change is large, prone to false level. Pay attention to judgment, in order to avoid misuse. 2. Steam pressure regulator (1) when the boiler must constantly monitor the pressure gauge indicated. To maintain stable steam pressure, boiler pressure must not exceed the design pressure. (2) increasing the boiler load: Steam pressure decreased boiler load is increased, if the level is high at this time, the amount of water should be reduced to a water supply or suspend, the amount of coal and increase the air volume. Gradually increase the amount of water at the same time to strengthen the burning, keep the steam pressure and the water level is normal. (3) boiler load reduction: the vapor pressure rises to reduce boiler load, if the level is high at this time, the amount of coal should be reduced and the air volume, reduced combustion. Then the appropriate water reduction or suspension of water supply to the water vapor pressure and stability in the nominal range. Then press the normal combustion and to adjust the amount of water. If the actual water level within the boiler is low, to increase the amount of water should, until the water level returns to normal after the combustion and needs to be adjusted according to the water vapor pressure and load changes. 3. Combustion adjustment (1) combustion index. Normal combustion boiler comprises a uniform supply of the fuel, reasonable ventilation, adjusting three basic aspects combustion. B. maintain a high temperature of the combustion chamber temperature of the upper layer is preferably in the 1100-1300 ℃, flame orange in color. Flame reddish color indicates that the amount is not enough to the wind, the color white indicates that excessive wind. It should be appropriately adjusted. C. fuel ash to reduce ash content in the combustibles to be below 10%. d. reducing the temperature of the exhaust gas boiler exhaust gas temperature should be controlled below 200 ℃. e. excess air negative pressure holding furnace boiler 1.2-1.4, by adjusting the balance of the blowers to maintain the furnace pressure is 2-3mm. F. to improve the thermal efficiency of the boiler thermal efficiency of the boiler should be kept above 60%. (2) adjusting the combustion a. Reasonable amount and the distribution of fuel to the amount of air needed for combustion. Ventilation should first increase the amount of fuel increases, it should first reduce the amount of fuel supply reduced ventilation. b wind principle feature: burn promoting intermediate ends. That is, after the coal into the coal starts to warm up the shutter, fire line front arch, the primary combustion zone, the middle grate to burn the rear grate zone. c is the normal combustion conditions: fuel ignition start at 300mm from the shutter of coal, even flames, the fire bed formation, at the end away from the combustion grate at the end of 300-500mm. d. Hold appropriate furnace temperature to avoid coking. E. fire bed to maintain the homogeneous combustion, to avoid burning fire bed obliquely. F. less than 30 minutes residence time of the fuel on the grate. Our company provides services related to the installation of the boiler!

Gas-fired 20 th dual fuel and steam boiler precautions recommended to do the work gas boiler in a safe basis, especially in peacetime personnel engaged in equipment operation. Gas hot water boiler with environmental protection, energy conservation, safety, salient features fully automatic operation, and ease of use. In addition, due to the operation of the economy, government policies to encourage, gas hot water boiler more and more people of all ages. Hot water boiler boiler assembly PC-style controller, all functions are stored on a smart chip, intelligent boiler, digitization, automation, humane, intelligent control of boiler water temperature, water temperature reached the heating automatically stop; large screen fonts display temperature, boiler water temperature at a glance. Biomass boiler categories: biomass boilers Horizontal, vertical biomass boilers. Biomass gas thermal oil heaters, biomass steam boiler, biomass hot water boiler, biomass oil furnace. In the production design, the device itself many, the safety factor is not perfect, operation mode, operation cycle, maintenance cycle so severely restricted, this is the most effective way to ensure security. The use of safety problems in gas steam boiler steam boiler gas, I believe not many people are familiar with. Below, we will be familiar with them and understand them together. I want everyone to standardize their own way. This is key to ensuring security and stability can not be ignored. Installation site and check before installation, there are very important considerations. Must be a good gas steam boiler and to be mounted and fixed on the solid ground plane selection concrete. Steel Fibers tell you, if there is abnormal companions at work, should cease immediately, so as to avoid more serious damage to the operation of the gas boiler, it is recommended on the basis of safety, especially in peacetime personnel engaged in equipment operation. In the production design, the device itself many, the safety factor is not perfect, operation mode, operation cycle, maintenance cycle so severely restricted, this is the most effective way to ensure security. The use of safety problems in gas steam boiler steam boiler gas, I believe not many people are familiar with. Below, we will be familiar with them and understand them together. I want everyone to standardize their own way. This is key to ensuring security and stability can not be ignored. Installation site and check before installation, there are very important considerations. Must be a good gas steam boiler and to be mounted and fixed on the solid ground plane selection concrete. Steel Fibers tell you, if there is no normal companion at work, it should be stopped in time to avoid more serious damage.

To speed up the transformation of coal-fired boiler project, the Tianjin Municipal Government were tender for coal-fired boiler products. In the bidding site, a number of boiler prosperity across the country have resorted to every means, come to bid on his own star product. Fang fast low nitrogen water tube boiler with its unique architecture and technology, will come to the fore in this bid, the successful bidder Tianjin Justice Drive surrounding district project.