Dealer Energy Saving 6t gas boiler Kuwait

Boiler installation of "blast doors," What is the role now on the market most of the dealer energy saving 6t boiler kuwaits to gas, oil, biomass, electricity as the main fuel, coal-fired boilers because of its harmful pollution levels gradually been changed or replaced. In general, no boiler explosion during normal operation, but if it is due to the improper operation of the ignition or operation, it may cause the furnace or tail or secondary combustion flue explosion, resulting in serious danger of impact. In this case the role of "explosion vent" is manifested when the furnace or flue trace knocking occurs, the pressure within the furnace is gradually increased, when a certain value is higher than the pressure relief device can turn on itself through the explosion vent to avoid the risk expansion to ensure the overall safety of boiler and furnace wall, more importantly, it is to protect the safety of the boiler operator. Currently there are blasting boiler membrane and two kinds of swing-proof door. Swing-proof doors are mostly placed in the furnace wall of the combustion chamber. Their installation position can be divided into vertical and tilting, by the door frame, the door and the hinge member and the like components. The door frame and multi-cast iron round or square, the width of their mutual contact surface generally is 3 ~ 5mm, and to ensure seamless tight. The door is coated with a heat-resistant concrete, which limit the pressure according to a desired thickness value has been calculated or determined experimentally. When the gas in the furnace or flue explosion, the door is automatically turned about the shaft relief, and then shuts itself down. Sealing pressure of the vent door from the inclination angle (usually not more than 30 °) or the downward pressure created by the weight of a weight is obtained. Most membrane blasting explosion vent means on the flue, and a clamping device consisting of explosive membrane. Bursting disc is typically made of a thin metal plate of asbestos, aluminum and stainless steel. When an explosion occurs in the furnace or flue gas generated shock wave pressure to bursting membrane damage, play the role of relief, once the explosion vent membrane after blasting effect, it will not reset itself, the clamping device must be open blasting repositioned membrane. Note 1, the position of general device explosion-proof door on the wall or on top of a steam boiler furnace furnace exit side of the furnace flue fuel gas. 2, explosion-proof doors should be installed in place without the threat of operator safety, and a pressure relief guide tube, it shall not be stored near inflammable and explosive materials, highly preferably not less than 2 meters. 3, activity blast doors require regular manual test to rust dead.

Gas central heating dealer energy saving 6t boiler kuwaits: For a long time I had coal resources are a big country, according to the relevant department statistics national energy use of coal in energy utilization percentage of 70%, the data currently in the world in terms of only four countries is the case (DPRK , Poland, South Africa, China), we can say more than half of the region are due to sub-state pollution, and therefore to change this situation for the benefit of our children and grandchildren is the only solution! This occurs when the fuel gas-fired boiler is that we, step by step out of China's haze cited under the lights, fuel gas-fired boiler is to gradually shift our energy agency oil, gas from coal, clean fuel raw materials such as fuel booster.

Startup dealer energy saving 6t boiler kuwait steam temperature does not mention how high do? A: In the unit to start the process, often encounter steam pressure has reached the requirements, and the steam temperature was too much difference, especially in front of the turbine and the blast furnace or red switch occurs. Should take the following measures: appropriate to increase the amount of coal to improve the furnace heat load; adjust the secondary air ratio, increase the amount of lower secondary air; improve wind, air pressure, increased gas velocity; hydrophobic and full of air and exhaust mother pipe in front of the main steam isolation all hydrophobic.

Recently, Binzhou City, Shandong Province High-tech District Supervisor Bureau to carry out special rectification actions dealer energy saving 6t boiler kuwaits within the region, mainly to effectively prevent and resolutely curb special equipment accidents from happening again, strengthen security principal responsibility.

Inspectors use of "without warning, went straight to the scene" way of checking for nine boiler units within the region conducted a comprehensive inspection, focusing on aspects of boiler operation, the operator of personal responsibility, troubleshooting, safety test accessories, etc. a comprehensive investigation. Long-term idle boiler, supervise the use of units in time for deactivation procedures; management is not in place, there are security risks of the use of units, ordered deadline to complete the hidden rectification. The campaigns, check out a total of more than 30 people, to identify risks at 8, at the completion of the rectification 8.

Next, Binzhou City High-tech Zone Market Authority will continue to strengthen law enforcement and inspection efforts, compacted layers of responsibility, and strengthen security consciousness, special equipment to protect the region's security situation continues to stabilize, escort for the economic development of high-tech zones.