bagasse hot water boiler in sri lanka

When using heavy oil, heating and steam boiler check the fuel control means, and switch on the view oil burner tube group. Advisory oil viscosity required from the manufacturer to ensure that the burner is working properly, and regularly check the heavy oil or residual oil viscosity to meet the requirements.

Works condensing gas boiler flue gas temperature is one of the basic parameters of the boiler, choose a lower exhaust gas temperature can be reduced boiler flue gas loss, help to improve the thermal efficiency of the boiler. If the boiler flue gas temperature dropped to a low enough level, then the smoke was overheated water vapor will condense and release latent heat of vaporization. Condensing gas boiler is the use of flue gas condensation heat recovery efficiency of latent heat is absorbed in the rear of the boiler flue gas and the sensible heat released by condensation of water vapor, to achieve the purpose of improving the thermal efficiency of the boiler. Condensing gas boiler can be recycled fuel type and boiler water temperature and how much water vapor the latent heat boiler flue gases are using. When the ordinary recovery boiler combustion gas without condensation, the heat efficiency of the boiler if the calculated calorific value of the fuel was 90%, the use of condensing heat recovery unit, the exhaust gas temperature down to 30 ~ 50 ℃, the thermal efficiency will be increased to about 107%. Fuel combustion will produce large amounts of CO2, NOX, and small amounts of SO2, these substances into the atmosphere, causing acid rain and the greenhouse effect, damaging effects on the environment. While condensing boiler flue gas condensate in the water vapor, it can be conveniently removed these harmful substances in the flue gas, therefore, use of condensing gas boiler is also of great significance for the protection of the environment. Choose a lower exhaust gas temperature can be reduced boiler flue gas loss, help to improve the thermal efficiency of the boiler, save energy and reduce operating costs. It is estimated that the boiler flue gas temperature is not higher 13 ℃ heat loss will increase 1%. However, the tail will decrease the temperature of the heating surface of the boiler flue gas exhaust and the heat transfer temperature and pressure working fluid is reduced, the heat transfer area is increased, further, the exhaust gas temperature is too low can also cause severe corrosion of the heating surface. Condensing gas boiler flue gas heat recovery using corrosion-resistant stainless steel production, significantly extended the life of the boiler.

It provides fast side of boiler equipment, installation and commissioning after all normal, we immediately put into use, the hotel did not delay the normal heating. Meanwhile boiler capacity, energy efficient, fully able to meet the needs of heating and bathing water in our hotel rooms. --customer feedback

Gas heating boiler room gas leak and cause harm to gradually push the past heating season, gas heating boiler purchase market is also growing, so in the course of the gas boiler in use, because this or that reason inevitably arise each kinds of unexpected situations, such as natural gas leaks, then what is the reason that leaked, would cause those risks? Normally natural gas leak can be divided into many categories, such as gas boiler leak, gas leak, and the boiler operation process, the influence of leakage and other components. Causes 1. Boiler body will have a lot of leakage, such as boiler body welded in place in the process; the process of boiler operation, non-compliance operation, resulting in the boiler corrosion, a long time will cause the furnace wall thinning and leakage phenomenon. Case closed lax view of the fire hole, explosion-proof doors, etc., can also cause leakage phenomenon. 2. As for the other components, it may be not flexible because the switch during operation, the closed lax air leak caused by gas heating boiler leak. 3. The reason burner leak is because the pre-design and installation does not follow the normal steps to take, leading to cases of post-fuel ratio imbalance, mutation combustion conditions. Boiler leak caused by the impact of the harm is relatively huge, gas heating boiler during operation, the emergence of this phenomenon, coupled with the natural gas in case of fire and other flammable properties, is likely to cause accidents boiler explosion, or to related businesses institutions incalculable loss. Therefore, in the process gas heating boiler use, be sure to regular maintenance, troubleshooting, if it is found at the occurrence of the boiler can cause leakage, timely maintenance, replacement, so as to avoid unnecessary losses.