gas fired steam boiler in gulbarga

The main structure of a natural gas boiler consists of a boiler shell, a tank, a switching chamber, a smoke pipe, etc. The boiler is suitable for various fuels such as light oil, heavy oil, natural gas, liquefied gas, and so on. The boiler has a reasonable structure and a double-layer reverse burning. It is beneficial to make full use of flue gas, and has the characteristics of small area, convenient installation and good steam quality. The working principle of natural gas boiler is: the water enters the boiler through the inlet, the water quality that meets the heating standard after the boiler is heated, the water is fed into the indoor radiator through the circulating pump, the heating is heated by radiation and convective heat transfer, and the water flowing through the radiator is flowing through the water of the radiator. Go back to the boiler and heat it up, and then go back to it. It flows into the radiator, so that it circulates over and over again. Moreover, the natural gas boiler system can also provide users with hot water to meet its basic needs, the temperature of the water quality in the boiler and the indoor temperature, after temperature sensor processing, the temperature signal is transmitted to the single-chip microcomputer. Through the corresponding driving circuit, to adjust the size of the corresponding pipe valve, and then by controlling the water quantity to control the water temperature, to achieve the purpose of heating, the user can also select the appropriate circulation pump according to the size of the heating range. This is also more economical and convenient.

If you know a little about chemistry, you may know that the sulfur content of oil and coal is roughly equal, but ask what low-temperature corrosion of oil-fired boilers is much more serious than coal-fired boilers, for two main reasons:

1. 90% of ash in coal-fired boiler, especially coal powder furnace, is taken away by flue gas, sulphuric acid steam formed in flue gas is absorbed by fly ash in flue gas, so that sulfuric acid vapor in flue gas is reduced, and about half of sulfur remains in ash when coal is burned. When the oil is burning, the sulfur content in the fuel almost all changes to the ash in the SO2, fuel, the fly ash in the flue gas is very little, and the adsorption ability to the sulphuric acid vapor in the flue gas is very weak.

2. The hydrogen content of oil in the oil-fired boiler is about 11%-12%. The combustion of each ton of fuel oil can produce about 1 ton of water vapor, and the partial pressure of steam in the flue gas is higher than that in the case of coal-burning.

Corner tube fired steam boiler in gulbarga is one type of chain grate steam boiler. ZG manufactured corner tube biomass fired steam boiler’s power is among 6 to 15 MW. This biomass fired steam boiler adopts corner tube pattern, self-supporting structure. The furnace and the descending fuel gas duct adopts total welding membrane water cool tubes wall structure, which has benefits of good sealing, lower heat reducing. Both air pre-heater and economizer adopt case pattern structure which is convenient to transport and install. As a top steam boiler manufacturer in China, our single drum corner tube biomass fired steam boiler made in China is both eco-friendly and high efficiency.

Since the occurrence of Zhangjiakou City, February 28th a tragic accident 15 tons of biomass boiler explosion (caused 3 dead 7 injured), Hengshui High-tech Zone Branch of monitoring the quality of the region's rapid convening of an emergency boiler safety special rectification will deploy a total of more than 60 home boiler unit, install the unit to participate.

At the meeting of the relevant provisions of the "Special Equipment Safety Act" Publicizing a comprehensive and read the "Hengshui City High-tech Zone boiler special rectification action plan", will use a month's time, carry out a comprehensive risk investigation to ensure the region's security boiler . Special Inspection Branch of the provincial hospital Hengshui boiler room main person in charge of inspection requirements for boilers and risk points were explained in detail.

The meeting stressed that all units should deeply learn boiler explosion safety lessons from the accident occurred recently around the country, and continuously enhance the sense of responsibility, strengthen risk awareness, problem seriously put their own problems and routine regulatory inspection found hidden in a timely manner rectification, study and solve countermeasures. To step up publicity on the one hand, and the regulatory authorities to supervise boiler unit to improve the system and strengthen the boiler safety training to improve skills of workers boilers, prevent illegal operation; on the other hand, vigorously promote the special equipment and boilers and other laws and regulations use common sense, use boilers to improve safety awareness, enhance self-awareness and self-protection ability of the masses. By month renovation, so security was tubes, equipment information, personnel documents, maintain dimensional record. Meanwhile, the number of law enforcement agencies to investigate and punish illegal cases, the exposure of some illegal businesses, education, warning a number of luck in the use of units, and strive to create "Care for life, concerned about security," a good social environment.