High Efficiency Distributor 20t Natural Gas boiler Georgia

Fuel gas control step and the blowing process air volume of the total fuel gas steam high efficiency distributor 20t boiler georgia steam boiler is achieved by adjusting a liquid coupling scoop blower. Organization fuel gas steam boiler combustion, is to make a, air pressure, air flow of secondary air with the good. Adjusting the amount of primary air should meet it carries the fuel into the furnace ignition of volatile oxygen required, and to maintain a certain speed, and without clogging the fuel discharge pipe of the jet having a certain rigidity. Primary air volume is too large and too small, the wind speed is too high and too low, should be avoided. In addition to adjusting the secondary air of combustion of the fuel should ensure that the oxygen demand, but must maintain a certain wind speed and primary air is mixed with the master time should have a strong stirring and mixing coke penetrate "the Gray" kinetic , which requires the case may be, each layer of the secondary air flow rate, in order to achieve stable combustion and flue gas excess oxygen appropriate destination. Fuel gas steam boiler, secondary air with what is better? Primary air volume air volume of the total share is called the primary air rate. A small air fraction, pulverized coal is heated to at least the heat required for the ignition point, fire faster, but the amount of primary air to satisfy the principle of combustion of volatiles. Secondary air mixed with the primary air time to the right. If it is mixed before ignition, means an increase in the amount of primary air, so that the ignition delay; hypoxia combustion secondary air if mixed will make late after ignition; if secondary air is mixed all at one position, since the secondary air temperature well below flame temperature, the flame temperature decreases, the combustion slows down, causing the fire. Therefore, the secondary air mixed with fuel should be based on the nature of the combustion zone as required timely sent, so that the combustion of oxygen, and will not reduce the flame temperature to ensure complete combustion and ignition stability. One or two wind speed with what is better? Fuel gas steam boiler once the wind speed is high, the fuel gas stream will catch fire in places far away from the burner, the ignition point postponed; once the wind speed is too low, it will cause a blocked ducts, and ignition point is too far forward, the burner will burn , but also easy to coke near the burner.

Recently, the Xinjiang region issued on the overall strengthening of environmental protection and resolutely fight pollution prevention tackling embodiment, the program provides: Complete with ultra-low emissions and energy-saving transformation of the conditions before the end of 2020, coal-fired power plants. Gradually shutting down key areas do not have the conditions for the transformation of highly polluting coal-fired power plants.

Implementation of the program focus on the regional party committee, "1 + 3 + 3 + reform and opening up" work arrangements, accelerate the construction of ecological civilization system to ensure that by 2020 the basic layout of the formation of the main functional areas, land space development pattern was further optimized, the total emissions of major pollutants and the amount of energy consumption per unit of GDP dropped significantly, significantly reduced the number of heavy pollution days. Specific indicators: the region of fine particulate matter (of PM2.5) concentrations of the standard level cities not decrease by 15% in 2015, the level of urban air quality days ratio reaches 71.6%; good monitoring of river water quality of the region (or superior to class III) ratio of not less than 97.6% (national quality evaluation section 47 excellent no less than 91.5%, worse than Grade V ratio of not more than 4.28%), focus on monitoring water quality of lakes and reservoirs of not less than 71%; sulfur dioxide , nitrogen oxides, chemical oxygen demand, reduce ammonia emissions into the 2015 3%, 3%, 1.6%, 2.8%; contaminated land safety utilization rate of 98%, contamination of land utilization is not safe less than 90%; the red line accounted for ecological protection area of ​​not less than 25%; forest coverage rate reached 5.6%.

Program has clearly pointed out, we must strictly control the total coal consumption, accelerate the use of clean energy alternatives. Study the development of the region's total coal consumption embodiments and independence - - "Kui" Ukraine - - Chang stone "of the total area of ​​coal consumption Ukraine" reduction plan, the implementation of the target responsibility management, controlling the total coal consumption. Delineation work carried out high-pollution fuel combustion zone ban, ban the sale in the region ban on burning, burning high-polluting fuels. Increasing the use of clean energy, clean energy consumptive broaden the channels, the implementation of policies for renewable energy generation full protection of the acquisition. Promote clean low-carbon energy sources priority access. Encourage waste heat, shallow geothermal and other clean energy sources for heating. Strengthening the CBM (coal gas) utilization, in an orderly bulk coal in key areas of governance, the implementation of biogas projects.

The implementation of comprehensive improvement of coal-fired boilers. The promotion of clean and efficient coal-fired boiler, strict implementation of coal-fired boiler emission standards. The region above the county level cities and built-up area basically eliminated 10 tons of steam per hour coal-fired boilers and furnaces and tea, operating the stove, grain storage and drying equipment, coal-fired facilities, in principle, to a new 35 tons of steam per hour coal-fired boilers, in principle, to the rest of 10 tons of steam per hour, a new coal-fired boilers. Ambient air quality did not meet the city should increase efforts to eliminate further. Key areas basically eliminated 35 tons of steam per hour of coal-fired boilers, 65 tons of steam per hour and above all coal-fired boilers to complete the transformation of energy-saving and ultra-low emissions; low nitrogen gas boiler basically completed the transformation.

In the region the implementation of ultra-low emissions and energy-saving coal-fired power plants, encouraging "Wu - Chang - Stone" to carry off white smoke fired power plant pilot area. Before the end of 2019 to complete the "Wu - Chang - stone" "Kui - ultra-low emissions and energy-saving black" area, and Korla Ili River Valley and surrounding areas with the transformation of the conditions of coal-fired plants, in other areas before the end of 2020 - only carry out. Gradually shutting down key areas do not have the conditions for the transformation of highly polluting coal-fired power plants.

Over the next three years, the Xinjiang region will strictly implement the Plan of Action to win the Battle of Blue Sky, "the Wu - Chang - stone" "" Kui - alone - Ukraine "and other key areas as the main battlefield, promote industrial structure, energy structure, transport structure adjustment and optimization, strengthening regional joint prevention and control measures to deal with weather and heavy pollution, further clarify reduce the concentration of PM2.5, and significantly reduce the number of heavy pollution days, significantly improve air quality, enhance the blue sky happiness of the people make unremitting efforts.

Startup high efficiency distributor 20t boiler georgia steam temperature does not mention how high do? A: In the unit to start the process, often encounter steam pressure has reached the requirements, and the steam temperature was too much difference, especially in front of the turbine and the blast furnace or red switch occurs. Should take the following measures: appropriate to increase the amount of coal to improve the furnace heat load; adjust the secondary air ratio, increase the amount of lower secondary air; improve wind, air pressure, increased gas velocity; hydrophobic and full of air and exhaust mother pipe in front of the main steam isolation all hydrophobic.

About condensing high efficiency distributor 20t boiler georgia: major cities are now facing a wide range of frequent haze weather body, the use of new clean energy - natural gas as a heating source distributed urban heating is very important imperative way around also it has begun to implement a large area of ​​the "coal to gas". And environmental protection and energy conservation must be combined in order to have a long-term mechanism. Natural gas condensing boiler premix gas heating than with traditional gas boiler heating heating costs can be reduced more than 30%, while the low NOx combustion techniques premix can be reduced more than 70% of nitrogen oxide emissions for natural gas efficient use of lower emissions and provides an efficient way.