gas container steam boiler

Successful ignition of fuel container steam boiler can not run, because of those common oil gas powered steam boiler applications, all of you should ignite the fuel steam boiler in the application process, no way ignition is also the most common problems. Fuel steam boiler in the application process, most likely resulting in no way ignition, resulting in fuel steam boiler can not run normally, small series to introduce you to a steam boiler does not ignite the fuel to run those common reason. Fuel steam boiler can not run common ignition of those reasons: First, the ignition problems: pulse ignition and control systems such as the one of which has caused the problem, the fuel steam boiler can not start. Second, the battery thing: to be very important to see if the battery is a battery in the end is not too aging. The charge is not standard, the same can not let steam boiler fuel ignition. Third, the water pressure thing: at the inlet steam boiler fuel filters block the formation of water can not flow normally through the clean up clean ok. Fourth, the pulse valve problems: If the boiler ignited fuel vapors to ignite division saw sound, no pulse valve "despair" squeak, probably for the pulse valve is damaged or degraded, pulse valve degeneration, will not manipulate, the beginning of the ignition operation when closing a flow will hit a fire, but the fire immediately and confinement; pulse valve before confirm whether there is a problem to confirm whether normal ignition actuating member, if the fault can not pull the valve actuating pulse. V. ignite feelings needles or needle thing: fuel steam boiler ignited hand shift. You can change or correct the ignition pin arrangement; if feelings of degradation promise things, as long as the feeling wiped clean arranged on it. Six, usually no way to exhaust smoke tube. Smoke tube steam boiler with a fuel block, clean breathing tube blockers smoke tube is too long, the configuration is not correct. Referring may be configured to inform two coaxial cigarette heater tube. VII vapor setter joint problems: fuel steam boilers, water vapor degradation intimal flap valve or joint damage, not the weak control push button switch; weak bad control switch button.

Classification bottom side Henan hot water boiler fuel boiler fast small as we explain the use of hot water boiler fuel What are assembled into a notebook-type water tube furnace control panel, all of the action are stored on the smart chip, maintaining a furnace automation, intelligent, intelligence and personalization, to keep the Zidongkongzhi furnace temperature. This hot water boiler is the energy conversion facility, the type of kinetic energy of the furnace with a fuel chemical energy, electromagnetic energy, heat energy, etc. smoke, and after converting furnace, must be provided outside the output energy of steam, hot water or inorganic heat carrier. Gas boiler effect ignition system and fuel gas is ignited depending on the compound, the key member includes: an ignition transformer, electrical ignition stage, electric high-voltage cable fire. Compare Security Council this ignition system called electronic pulse ignition, such as natural gas is Zhuoyi energy-saving boiler manufacturers widely used. Its convenient and save time, as long as the finger can be pressed, and high safety factor, because life is not prone to production safety accidents death Xihuo arise, if the situation Xihuo appears, immediately turn off the control relay, off-gas loop . Computer processing furnace boiling hot water boiler part of the control panel, all functions are stored on the smart chip, maintaining the automated, intelligent and personalized furnace, furnace temperature to achieve a Zidongkongzhi. Automatically terminate the heating temperature is too high; the display font size to display the temperature, boiler water temperature straightforward. Exceeds the temperature was warmed automatic termination; display font sizes that vary depending on temperature, the furnace temperature simple. 2. boiler water temperature can provided 10 ℃ ~ 100 ℃. The furnace can not only produce bath with boiling water, boiling water can produce consumption, either to the furnace, but also to the furnace. 3. The top vents under the furnace wall, furnace in the non-pressure situation, the explosive risk-free, bare metal provisioning with over-temperature maintenance (inside the furnace when the temperature is high, heat pipe automatic termination of work to do, and came bee song alarm). Again when maintenance overtemperature (secondary circuit is automatically disconnected when the temperature exceeds 105 ℃ furnace shell), and less water to avoid air burning maintenance (water is less than when the furnace is very low amount of water in the secondary circuit of the furnace shell temperature exceeds 105 ℃ auto-off), when the water is less than the low water furnace automatically disconnect the secondary circuit, the furnace terminate work to do and came buzzer alarm) and other security Council safeguards. Much of this hot water boiler is converted from a hot water boiler is made early, it should belong to the ecological pot of water through the bad within the furnace. To ensure the safety and reliability of the coefficient of water circulating furnace, the furnace has to be a predetermined aspect ratio, and thus a large volume of such a heating furnace, the steel consumption and to enhance profits depend.

Zhengzhou Sunrise Optoelectronics Technology Co., Ltd. by the Dongxu Group, Henan Province, the state-owned asset management companies and Zhengzhou Investment Holdings Limited jointly made, mainly engaged in flat panel display and solar industry design materials, manufacturing and sales operations. Sunrise Optoelectronics project has been put into a production line, the second phase will continue the expansion, three new production lines to meet the production needs of Project Phase II, Sunrise Optoelectronics urgent need to increase new boiler equipment. After investigation and screening of a number of boiler brands, determined to cooperate with the fast boiler, steam signed a 10-ton integrated condensing gas container steam boiler (WNS10-1.25-Y.Q).

20 ton oil gas container steam boiler in a pharmaceutical factory

As we mentioned earlier, steam boilers are of great significance in pharmaceutical companies. We have supplied a 20-ton oil gas steam boiler to a pharmaceutical company overseas. In this pharmaceutical company, steam boilers provide heat for the disinfection of raw materials, sterilization of utensils, and drying of tannins. Our technicians provide customers with a 20 ton wns series oil gas steam boiler based on the information given by the customer.