Distributor 4t Natural Gas boiler Industrial Indonesia

2, various post-combustion treatments

Many of the coal ash will happen after combustion in the boiler, in order to safeguard the health needs of the environment will be transported to the ash professional processing slag field, however, the use of gas-fired boiler is gas, there will be no remaining after combustion ash, so do not need to process it, not only to avoid the formation of environmental pollution also decreased the labor intensity and the amount of urban ash storage and transportation companies.

Fuel gas control step and the blowing process air volume of the total fuel gas steam distributor 4t boiler industrial indonesia steam boiler is achieved by adjusting a liquid coupling scoop blower. Organization fuel gas steam boiler combustion, is to make a, air pressure, air flow of secondary air with the good. Adjusting the amount of primary air should meet it carries the fuel into the furnace ignition of volatile oxygen required, and to maintain a certain speed, and without clogging the fuel discharge pipe of the jet having a certain rigidity. Primary air volume is too large and too small, the wind speed is too high and too low, should be avoided. In addition to adjusting the secondary air of combustion of the fuel should ensure that the oxygen demand, but must maintain a certain wind speed and primary air is mixed with the master time should have a strong stirring and mixing coke penetrate "the Gray" kinetic , which requires the case may be, each layer of the secondary air flow rate, in order to achieve stable combustion and flue gas excess oxygen appropriate destination. Fuel gas steam boiler, secondary air with what is better? Primary air volume air volume of the total share is called the primary air rate. A small air fraction, pulverized coal is heated to at least the heat required for the ignition point, fire faster, but the amount of primary air to satisfy the principle of combustion of volatiles. Secondary air mixed with the primary air time to the right. If it is mixed before ignition, means an increase in the amount of primary air, so that the ignition delay; hypoxia combustion secondary air if mixed will make late after ignition; if secondary air is mixed all at one position, since the secondary air temperature well below flame temperature, the flame temperature decreases, the combustion slows down, causing the fire. Therefore, the secondary air mixed with fuel should be based on the nature of the combustion zone as required timely sent, so that the combustion of oxygen, and will not reduce the flame temperature to ensure complete combustion and ignition stability. One or two wind speed with what is better? Fuel gas steam boiler once the wind speed is high, the fuel gas stream will catch fire in places far away from the burner, the ignition point postponed; once the wind speed is too low, it will cause a blocked ducts, and ignition point is too far forward, the burner will burn , but also easy to coke near the burner.

2 sets gas oil fired steam distributor 4t boiler industrial indonesia

The production line uses 2 sets of 10 tons of oil gas fired steam boiler (integrated condensing type), which is fully intelligent in English operation, so that boiler management personnel can feel the advanced technology. Dynamic display of boiler operating status, all parameters on the big screen at a glance, more than 10 kinds of safety warning devices, with peace of mind. The most critical is the advanced condensing technology, which saves a lot of fuel costs per year compared to ordinary boilers, which means efficient production and lower costs.

Fast distributor 4t boiler industrial indonesia based on the local, to the world. In 2013, Alliance Group and Indian steel companies entered into a collaboration to deliver four single 26.7 tons of steam shell type boilers, famous at home and abroad.