gas fired hot water boiler in chennai

Note Di steam boiler steam boiler operational considerations should use great caution when using, because the slightest error will bring harm, so the operation should be more cautious, for a description of the use of steam boilers, process clear operation should pay attention It matters. Biomass boiler is a kind of boiler to biomass energy as a boiler fuel called biomass boilers, steam boilers into biomass, biomass fired hot water boiler in chennai, biomass stove, biomass thermal oil heaters, vertical raw biomass boilers, biomass boilers and other horizontal. Steam boiler is an energy conversion device, the energy input to the boiler fuel chemical energy, electrical energy, thermal energy and other forms of high temperature flue gas, and after converting the boiler, the steam output having a certain outside thermal energy, high-temperature hot water or an organic carrier. According to many years of experience in the use of steam boilers, summarizes the operating steam boiler matters should be noted: First, before the boiler to be familiar with the use of manual, to protect the normal use of safety equipment and operating personnel fundamentally. Before starting, check the power supply voltage is operating properly and water, close the drain valve to open the water supply valve, the pump checks whether the jam, remove the blade cover, and the motor shaft to the flexible state to start the scroll machine. Check the boiler or the power off when changing accessories to avoid the risk caused by the charging operation. Secondly, the electronic control box, pumps, motors and other components should be avoided in order to prevent moisture absorption burning boiler should pay attention to maintaining clean, according to the relevant boiler water quality requirements, be sure to install a water softener use, because they do not use a water softener can cause boiler fouling, serious it can cause burst pipes, shortening the life of the boiler. Finally, if the above conditions are not covered by the warranty, if not used in accordance with the provisions of water treatment equipment, sewage note that when used. Emissions once a day, with pressure 0.1MPa-0.15MPa emissions to prevent clogging pipes, sewage pipes should be connected properly to prevent burns, the safety valve should be flexible maintenance plans, pull the lever at least once a month safety valve to check its take-off and elastic seat. Local Technical Supervision safety valve should be checked once a year.

The main difference between the gas boiler and gas steam boiler What is the main difference between what gas boilers and gas steam boiler is? Nominally, a clear distinction between gas and steam boiler wherein the boiler fuel gas is different. The former use of natural gas, which uses coal. I think a lot of user concerns boiler is why they should cancel gas-fired boiler, because many people have purchased and used the gas boiler. If they switch to gas-fired boiler, it will be a huge expenditure. First, according to the current direction of development of the ecological environment of China, gas boilers will gradually be replaced by gas-fired boiler or other clean and green energy boilers, gradually withdraw from the stage of history. To say a big difference between the gas boiler and gas steam boilers, gas-fired boiler is mainly due to the elimination of environmental protection. From the fuel supply portion, only a gas boiler tube connected to the boiler; gas boiler needs coal field, coal (with or artificial), coal transportation, handling, storage and loading of coal boiler process. It will produce dust, causing serious pollution to the people's living environment. From the point of view of atmospheric emissions, natural gas is very small dust content, substantially negligible; high ash content of coal, the ash content of about 10-30%, the combustion smoke. If dust emission reduction facilities, emissions will increase; if more dust removal facilities, the corresponding costs will increase, this is not a long-term solution. In addition, the sulfur content of natural gas is very small, dust removal, desulfurization and denitrification can get gas boilers, gas boilers need only consider the denitrification problem. From the other point of view of waste disposal, natural gas substantially free of other contaminants, especially in city gas. In the case of coal, the coal field (especially small boilers mainly built in the open air) to produce coal slurry water during the rainy season, or sink into groundwater. When entering the surface water, the combustion ash conveyance of dust is generated. Of course, there are differences also in other ways. For small boilers, gas boilers are more energy efficient than gas boilers, equipment flow is simple, small footprint, low operating and maintenance costs, and so on. These are the main difference between the gas boiler and gas steam boilers, as well as the significance out of gas boiler. As can be seen, the use of gas-fired boiler is the trend of the whole society.

Around the city to promote the coal to gas project, the major institutions of the heating system put forward higher requirements. Central Conservatory of Music is available to students and teachers clean, safe, comfortable, energy-efficient heating environment, protect the health of teachers and students, to transform the traditional boiler treatment. Praise fast boiler Willie sharp series obtained in the transformation of low nitrogen boiler major institutions in Beijing, the Central Conservatory of Music in late 2017 with the signing of fast boiler boiler purchase contract, ordered six Willy sharp series V6-99, to for the entire school's heating facilities.

Coal-fired steam boiler auxiliary equipment which is the result of burning coal-fired steam boiler fuel coal fired boilers to provide steam for industrial production, with the rapid development of the national industrial production, market demand for coal-fired steam boiler gradually increased, boiler in addition to the main components, further include other auxiliary devices, such as coal feeder, induced draft fan and the like. As a supporting auxiliary equipment coal-fired steam boilers, related to an important indicator of whether the normal operation of the boiler, auxiliary equipment and its role following is a small series of analyzes and summarizes the coal-fired steam boiler: 1, fuel supply equipment: Storage and transportation fuels. 2, coal grinding and milling equipment: Pulverized coal milled to a pulverized coal burning and enter the combustion boiler combustion apparatus. 3, the wind blowing apparatus: the air blowing device is defined by the air into the blower means exports coal furnace air preheater after heating and milling. Blower device refers to the boiler flue gas discharged from the chimney draft fan and sent to atmosphere. 4, water supply equipment: water through the water treatment device processing into fired steam from the feed pump. 5, slag, dust removal equipment: Cleaner Equipment refers to the removal of ash from the boiler and carry away equipment, dust removal equipment refers to the removal of fly ash in the boiler flue gas, improved sanitation. 6, the automatic control device: automatic detection, process control, automatic protection and automatic adjustment. Advanced coal-fired steam boiler in a programmable logic controller (PLC) is the central processor of the control system. The control system via the touch screen operation, the boiler automatic control and degree of operational reliability is greatly improved, easier to use and intuitive.