Industrial Hot Selling 1t gas boiler Brunei

Second, grasp the "coal to gas," the key link.

1, removal of the original coal-fired boiler slag machine, coal hopper, coal equipment, chain grate, gearbox and so on.

2, by calculating the heat transfer in the furnace, the furnace geometry is determined, the center position of the furnace flame. Re-casting furnace, the furnace using the refractory castable

Coal-fired industrial hot selling 1t boiler brunei not only seriously polluted air, which produces a large amount of waste water sludge can also cause serious water pollution and soil contamination. To protect the city of Tongren green water blue sky, since 2014, led by the city of Tongren City, Guizhou Bureau of Quality Supervision, of 10 steam tons / hour within built-up areas and Tongren City High-tech Zone, Economic Development Zone, Tai Lung range and below, in Guizhou tobacco industry limited liability company Tongren cigarette factory, Tongren City, drug rehabilitation centers, Tongren Wantong construction and development Co., Ltd. and other 36 enterprises of coal-fired boilers to carry out an intensive diagnostic investigation. One by one on the ground to verify the registration, and the companies signed an undertaking to ban coal-fired boilers eliminated; to effectively reduce the burden on enterprises, according to the spirit of the document, to take the initiative within the time limit or eliminate the use of coal-fired boiler unit to switch to clean energy, the after review and acceptance Municipal Environmental Protection Bureau, according to the amount of coal-fired boilers hour evaporation reward, award criteria tons of steam per 30,000 yuan subsidy.

Up to now, the city of Tongren out of 36 coal-fired boiler units, a total of 43.051 tons of steam, an award subsidies 1,291,530 yuan, so far, the city of Tongren jurisdictions total phase-out of all coal-fired boilers, and lay a good foundation for the creation of ecological civilization demonstration area.

Factors which influence energy-intensive industrial industrial hot selling 1t boiler brunei energy-intensive industrial boilers factors influencing factors which have high energy consumption of industrial boilers which have 1, energy consumption is low management level industrial boiler is too large, are long-term presence of many companies in the current . On the one hand understanding of the enterprise energy conservation boiler is still not sufficient, on the other hand the energy management level is still at a low level, and even some companies even the most basic measuring instruments are not equipped. In order to reduce operating costs, many companies have to buy the old boiler use, lack of components purchased fuel means of inspection. Even in the case of raw coal screening is not performed, it is directly put into production use, it is difficult to ensure full combustion of coal. Not only the thermal efficiency is low, but also resulted in a waste of fuel. 2, heat recovery is poor combustion is incomplete, the situation is the high rate of heat loss is extremely common in industrial boilers used in the process, saving the main parameters of the boiler will be exceeded. Economizer function is to heat energy recovered, but in actual use, heat recovery efficiency is very low. In this case, do not use a lot of boiler economizer direct altogether, inevitably produce exhaust gas temperature is too high. Meanwhile, return the device and steam condensate recovery, it has not been fully appreciated and better use, some are put to use in the boiler after installation, and did not take appropriate measures to deal with poor recycling effect. 3, lack of effective supervision of the level of energy service work, depends largely on the level of experience and technical personnel. But in practical terms, due to the lack of technical personnel, resulting in the energy service work at the level of the low. Various enterprises produced energy-saving products with high imitation, coupled with the lack of effective supervision of energy-saving measures, resulting in the entire market of energy-saving products more confusing. The effect of not only energy-saving effect is not ideal, and to transform the poor, the performance of energy-saving products remains to be greatly improved. Market confusion, vicious competition phenomenon has not been fundamentally curbed.

We know the difference between fuel oil and gas industrial hot selling 1t boiler bruneis, gas or oil-fired boiler choice is not difficult to solve: first, to see if fuel oil sales unit is located within close range, then give up if no oil-fired boiler, long-distance transport will increase fuel cost. Second, you can understand the situation to the relevant units subscribed natural gas pipelines, though such early to spend more, but in the long run, can save a lot of money as a unit.