water tube light oil boiler

Boiler steam temperature affect the safety and economy temperatures above will be lower than the rated temperature of the device, it will have a bad effect. If the temperature exceeds its rated value, the water tube boiler will cause overheating of the relevant metal material, material creep acceleration, will shorten the life of the boiler. If the temperature is too high, but some of the key components of the boiler would cause damage, can also cause serious and even superheater tube rupture. If the temperature is lower than the rated temperature, vapor enthalpy is reduced, increased air consumption, decreased economy. This will reduce the thermodynamic cycle efficiency of the plant, the steam humidity at the last stage blades of the gas turbine increases, causing erosion and damage to water droplets gas turbine blades, affect the safe operation of the gas turbine. Ruoyin with water vapor causes a decrease in temperature, the moisture in the salt impurities formed in the superheater scale, pipe valves, gas turbine blade, because the superheater lead to reduced heat transfer, the temperature decreased, damage increased wall temperature; and cause the valve plug, the operation failure; and a gas turbine blade erosion, loss of balance and vibration occurs. Temperature fluctuations reason superheater actual heat transfer the vapor does not reach the required amount of heat absorbed corresponding balancing. When the heat absorbed is greater than the heat transfer, the temperature rise; conversely decreased. Many factors affect the temperature change, including both gas side and the vapor side. Such as boiler load increased, but also to ensure the boiler load unchanged or decreased in order to prevent pressure shall increase the amount of fuel and air supply, strengthen the burning, causing the furnace exit flue gas temperature of the flue gas volume increases and lower water temperature , temperature increase; If the oil and gas fuel is combusted in the furnace carbon black is not fully formed, into the superheater flue causing secondary combustion, but also greatly increase the superheat temperature. Reducing the temperature of the main reasons: improper adjustment of combustion, low flame center furnace; superheater area is small, or too much leakage at the furnace wall; Save water flow rising or temperature reduction; drum water level or high gas-water separator separating efficiency is lowered, the humidity of the vapor is increased; superheater tube fouling, reduced heat absorption and the like.

Some small knowledge about hot water water tube boiler

Hot water boiler is one kind of boiler, mainly because its medium is hot water. There are many kinds of hot water boilers, which can be divided into point hot water boilers, oil hot water boilers, and some more environmentally friendly gas and coal fired hot water boilers according to the fuel used. The working principle of hot water boiler is very simple, which depends on the heat energy of fuel combustion to achieve the function of heating water, it is a kind of simple heat energy boiler.

Dezhou City, Shandong Province, located in northern China, the winter heating livelihood security is the top priority. According to statistics, the main city such as the German city of existing heating water tube boiler 63 units, for the protection of the safe operation of the winter heating boiler, the past few days, the German city Bureau of Quality Supervision special equipment inspectors to carry out a comprehensive examination of special law enforcement actions against these heating boilers.

Check the main content around the registration and inspection of boilers, operator's safety if the holder case posts, etc to focus your heating boiler operating conditions, in particular the various safety accessories and safety devices especially by the attention of inspectors. By the inspection activities, it may be within the control range as much as possible, to ensure the safe use of heating boilers.

2.szs series oil and gas water tube boiler

With a capacity range of 6-35 tons, this szs series oil and gas boiler is a double-cylinder vertical quick-distribution water tube boiler with compact structure and low nitrogen emissions.