gambar boiler gas

Advancing the ignition point of coal, the temperature of the furnace to improve the ash carbon content decreased. Smoke swirling mix and strengthen the separation of coke particles in the flue gas, so that it falls on the fire bed and the new layer further fuel burn. Flue gas also strong swirl in the flue gas CO, H2, CH4 and other combustible combustion gases, thereby improving the thermal efficiency of the gambar boiler is more than 4%. But also improve the boiler output to meet the needs of the production of steam, reducing environmental pollution, expanding the scope to adapt varieties of coal. 2. The air supply and reasonable regulation. In Grate, vibration stove, oven and forth, depending on the characteristics of the combustion process, reasonable air, to promote combustion furnace is very important. As the chain furnace, with grate the fuel is kept in motion, occur sequentially ignition, combustion, burn various stages. Along the longitudinal direction of the combustion grate stages, the partition, the amount of air required in the grate longitudinal direction is different. In the preheating zone of the head and the tail of burnout grate stage, small air requirement in the middle stage of combustion grate, the air amount required.

Coal to natural gas operations bunch of factors that vertical pressure steam gambar boiler energy consumption indicators of the country are carried out in a big way, the choice of vertical steam boiler, to a large extent minus the pollution of powder, together with nitrogen oxides and other dangerous gases the press has been discharged. Energy consumption indicators is an important rule to measure vertical steam boiler, to discuss the next bunch of factors under pressure vertical steam boiler energy consumption indicators. By analyzing the relevant departments, vertical steam boiler heat loss occurs mainly includes two aspects: the proportion of non-standard sufficient combustion air with exhaust heat loss. Weaken the heat loss can be retrofitted in the vertical steam boiler chimney terminal latent heat of re-use form, or in the selection of better boiler system FGR. Combustion air ratio is not sufficiently decomposed inappropriate criteria: ordinary vertical ejector-type steam boiler burner based, air-fuel ratio can not be formed in the active mobilization. More vertical steam boiler based on a mechanical blower burner, air-fuel ratio due to the following standards several factors: air-fuel ratio standard comprises two situations: when oxygen is excessive, the excess will be an infinite cryogenic air by heat conduction, caused by rising energy vertical steam boilers, low energy consumption vertical steam boiler index; when there is insufficient oxygen, there will not be sufficient to ignite the situation, leading to low energy consumption indicators vertical steam boiler.

Recently, the Longhai carried out safety campaigns to the gambar boiler, the campaigns start from the four directions, whether units in accordance with the boiler 'boiler safety practices "to use the correct boiler conducted a comprehensive inspection.

First, the unit register in a boiler boiler inspection. The use of units to crack down on unauthorized use of untested or failed the inspection of boilers.

Second, the units are equipped with a boiler if the security officer and fireman personnel. Focus on checking whether the use of units as required "special equipment operator assessment rules," the fireman with security personnel and staff to meet the requirements, and whether the person has made fireman fireman card.

Third, in the boiler unit will be the safety management system, emergency plans to check the system; and to convey the importance of this inspection in the boiler unit, raise awareness of security units.

Fourth, strengthen supervision of energy-efficient boilers, boiler and actively promote energy efficiency testing, at present, boiler energy efficiency testing has been completed a total of 112 units.

To date, the Longhai inspection operations were dispatched inspectors 209 passengers, checked boiler unit 136, check the boiler 168 units, eliminate safety hazards at 9, and urge the use of sealed units to enhance the energy efficiency of boilers 21 units.

And with the Commission by letter, and environmental protection departments to further promote the comprehensive upgrade of coal-fired boiler energy saving project, disable the coal-fired boiler 53 units, 34 units scrapped, replaced by raw material boiler fuel and natural gas fuel of a total of 40 units, is out of the city coal-fired boilers to make a positive response.

Steam gambar boiler must be shut down? For gas-fired boiler will be some companies: the higher cost of oil-fired boilers and electric heating boilers, many SMEs simply can not afford, the thermal efficiency of the boiler is too low, gas consumption often can not keep up. Many reasons why gas boiler known as the preferred place of the main gas boiler. In business consulting to some customers learned, after being forced to shut down the gas boiler, no steam, the company has only discontinued. In order to survive companies only replace the boiler, to select the gas-fired, oil-fired boiler, electric heating boiler and a biomass pellet boiler. Currently the market for natural gas boilers only major selection, analysis of the reasons is that gas-fired gas boiler is fully automatic, with no pollution. But in reality, many businesses faced to replace the boiler, gas pipeline did not pull in place, some companies simply do not have natural gas pipeline, steam boiler must be shut down? Gas boiler gas boiler, not to mention the natural ventilation. This is the biggest obstacle currently facing.