Agent Price Energy Saving 4 ton coal boiler

Through estimation: If the exhaust gas temperature of 150 ℃, when the excess air ratio from 1.5 to 3.0 cases, the combustion is generally bituminous coal, anthracite agent price energy saving 4 ton coal boilers, heat losses from about 5% to 10%, reducing the thermal efficiency of the boiler nearly 5 percentage points. While the chain grate boiler excess air ratio was mainly due to leakage caused by the grate, but also accounted for a large proportion of the furnace leakage, strict plugging wind, to improve boiler thermal efficiency, reduce coal consumption, save energy resources it is very significant. Before plugging the wind, the first thing leakage test boiler.

Today I saw that when the capacity is the same, the furnace of the oil-fired agent price energy saving 4 ton coal boiler is smaller than that of the coal-fired boiler. Why? The specific reasons are as follows: the size of furnace volume, after the boiler capacity is determined, mainly depends on the volume of heat load. The size of the volumetric heat load is mainly determined by the type of fuel. After the fuel enters the furnace, it will take a certain amount of time to burn out. Fuel is usually required to burn out before it leaves the furnace. It is obvious that pulverized coal will burn longer than oil, that is, the flame of coal combustion will be longer than that of oil. In order to ensure the long-term safe operation of the boiler, it is necessary not only to prevent the slagging of the boiler, but also to make the temperature of the flue gas at the furnace outlet begin to change compared with the ash in the flue gas The temperature is 50 ℃ lower than 100 ℃ to prevent slagging at the furnace outlet and subsequent convection heating surfaces. The ash content of coal is more than that of coal-burning furnace, and the flue gas temperature of furnace outlet is 1050 ℃ and 1100 ℃. There is no danger of slagging in the furnace because of the low ash content in the oil, and do not consider the slagging problem of the slag discharge tube at the exit of the furnace, so the smoke temperature at the exit of the furnace can be higher.

Our hotel attaches great importance to environmental protection philosophy, always bear in mind the protection of environmental quality in Xiamen. Therefore, we chose to stay ahead of the fast agent price energy saving 4 ton coal boiler industry cooperation in clean and green boiler, electric steam boilers party fast to ensure that we provide the normal work requirements at the same time, has a very clear environmental performance. --customer feedback

Is more feasible briquettes may be employed, it will be used after vaporization, the residue after burning so that less amount of the exhaust gas is small too heavy discharged from the combustion, and the combustion heat value of the coal after vaporization is relatively high, so the use of more cost-effective in the heating agent price energy saving 4 ton coal boiler.