Commercial 1 ton Natural Gas steam boiler Turkey

Boiler multiple protection: (1) the integration of boiler water level to protect water level and boiler design, the appearance of more compact appearance, accurately show the actual water level in the boiler body function. Coupled with dual independent electronic water level control system to achieve ultra-low water level in the boiler, low water level automatic adjustment function, the normal water level, high water level, ensure that the boiler in a variety of unforeseen circumstances foolproof, secure home. (2) steam pressure protection ☆ pressure controller: selection of high sensitivity of the pressure controller, the pressure is high, or low levels of signal to the electrical switch, other control lines or automatic control chain protection. Common pressure controller and pressure gauge, vapor pressure overpressure alarm can cut off the burner limit is reached; the pressure controller may be single or double fire burning fire the actual operating pressure regulator. ☆ safety valve: safety valve is the last line of defense to protect the boiler, the boiler pressure exceeds the limit, according to the set pressure relief valve design with the school, the exhaust steam pressure relief, to ensure the normal operation of the boiler. (3) having a burner flame protection flame protection inlet means, combustion function is to detect, when the ignition failure or extinguish combustion middle, immediately off the burner into the oil (gas) solenoid valve, the blower continues to operate at this time, the furnace was purged combustible residual gas, after 20 to 30 seconds purge, and various auxiliary blowers automatically cut off power, the boiler operation stops. (4) self-locking power failure protection case, the boiler shutdown immediately burst self-locking power interruption, if the current power is restored, the boiler will not start at any time, you must reset release self-locking, to re-start the ignition.

Gas-fired commercial 1 ton steam boiler turkey steam boiler and gas accounted for half of the market at any time, more and more national attention to environmental protection, gas steam boiler has been hit hard. In contrast, gas steam boiler by many users of all ages. In recent years, also vigorously promote the use of gas-fired boiler. Gas-fired steam boilers What are the benefits? Let us discuss with you today. Gas-fired steam boiler steam boiler and gas market accounted for half of the market, showing a trend of resistance of court, but in the long run, gas steam boiler will obviously be the only dominant market. Do not believe, look! 1. Purchase costs: Obviously, in terms of technical gas boiler and auxiliary aids far ahead of the gas boiler, and is equipped with a special gas burner. 1 ton steam boiler, for example, gas boiler about 30% higher than the gas boiler. 2. Construction cost: This cost mainly from the boiler room. As more gas steam boiler auxiliary equipment, boiler house construction should invest more money. Less gas boiler auxiliary equipment, automatic control operation, with automatic alarm and automatic protection, saving the cost of housing, safe and reliable. After natural gas pipeline, the burner will automatically supply, cost-effective employee. Gas boilers also need to pay some wages, because they need to participate in coal plan. 3. fuel costs: You can clearly see this by looking at the actual specific fuel prices at each location. The fact is that the amount of coal burned per hour is much higher than the amount of gas. 4. environmental costs: In the need to protect the environment, the review of the gas boiler are becoming increasingly stringent. Because of the economy, environmental protection and energy as well as government policies, gas steam boilers more and more widely used.

About the kind of commercial 1 ton steam boiler turkey fuel oil boiler steam through the next, there are many main purpose, main features, a brief Automatic fuel gas steam boiler. A: The main purposes: food processing, printing and dyeing, pharmaceutical production and provide steam to provide steam sterilization, medical institutions, enterprises and institutions to provide steam for the other, the hotel's heating Automatic fuel gas steam boiler, the heating can also provide domestic hot water tank by . Second: The main features: 1, with central back burning structure, a large volume of water and gas boiler space, adaptable load capacity. 2, the indoor micro-pressure flame automatic steam boiler fuel combustion, the flame is fully extended, enhanced heat transfer, thereby reducing convective heating area, reducing the cost of the boiler. Smoke flow resistance is small, low-power consumption operation, operating cost savings. 3, in addition to the conventional four level height control, an additional level detector 5, the detection bit will stop when the boiler water, alarm, to ensure safe operation of the boiler. 4, the front smoke box special heat insulation materials, high temperature, low thermal conductivity, good anti-radical quenching heat capacity, greatly extending the life center back burning boiler before the smoke box, the furnace insulation is multilayer glass wool , light weight, low heat loss. 5, automatic oil-fired boiler steam pressure is controlled by Danfoss and Danfoss pressure controller and pressure transmitters joint control, pressure controller is responsible for ultra-high pressure interlock protection, prohibits burner working and alarm; pressure transmitter responsible for combustion engine to work to achieve some or all of control, to achieve automatic control of the exact steam pressure and steam pressure in the pressure range provided by a touch screen, detecting a pressure up to 0.002 MPa, more accurate pressure control. Thus avoiding a pressure controller general requirements of the production and the high vapor pressure of low pressure gas boiler or the actual requirements of the production of high pressure and low pressure gas boiler can not meet the disadvantages of the production requirements. 6, flue gas condenser fast side (optional) by the national utility patent, requires efficient use of steel-aluminum sheet Chi spiral tube heat exchanger, heat transfer surface is sufficient, the small side of the flue gas resistance of the system to meet the general burner. With flue gas condenser heat boiler efficiency can be improved more than 8%, the fuel gas savings of nearly 10%. These are the simple on automatic steam boiler fuel introduction want to be useful.

To continue to improve air quality and protect people's lives and health, Hainan Province, issued a "Hainan Air Pollution Prevention Regulations" (hereinafter referred to as "Regulations"), a clear implementation of the total coal consumption control system, and gradually reduce the amount of coal consumption, phase out existing coal-fired units. "Regulations" since March 1, 2019 into effect.

"Regulations" put forward specific requirements for coal and other energy pollution control.

A prohibited import, sale and burning of coal does not meet quality standards; prohibited the import, sales do not meet standards of quality petroleum coke; prohibition of burning petroleum coke. Above the county level department in charge of market supervision and management need to be strengthened coal, petroleum coke quality management, from time to time on coal, petroleum coke quality sampling.

Second, the people's government above the county level market supervision and administration departments shall, jointly with relevant departments in charge of the environment, industry and information technology, etc. According to China's Hainan Province and the relevant provisions to strengthen the supervision and management of boiler production, import, sale, use, etc., do not compliance with environmental standards or requirements shall not manufacture, import, sale and use. Phasing out coal-fired boilers. Existing clean energy such as natural gas-fired boilers, furnaces, low NOx combustion should be completed within the prescribed period of transformation of the people's governments above the county level department in charge of the ecological environment. New clean energy such as natural gas-fired boilers, furnaces and other facilities shall pollution control measures such as the use of low NOx combustion.

Third, the central heating has been implemented for the work (production) business park, a ban on new construction, renovation, expansion of decentralized heating boilers, heating boilers should be dispersed in the original city, county, autonomous county people's government department in charge of market supervision prescribed period in the demolition; work not yet implemented central heating (production) business park has heating demand should be in the city, county, central heating implementation as soon as possible within the time limit prescribed Autonomous County people's government department in charge of market supervision and management, and removal of the original dispersion heating boilers.